Influence Produced by the Operation of the Power Units of Thermal Power Plants in the Maneuver Load Mode on the Reliability and Accident Rate of Power Equipment
DOI:
https://doi.org/10.20998/2078-774X.2016.08.14Анотація
Due to the insufficient amount of maneuver powers for consolidated power systems in Ukraine pulverized-coal units that were designed for the operation in the base section of the schedule of electric loads are used for the power control. The current state of energy generating equipment available in Ukraine has been analyzed, the drawbacks of the operation of power units with regard to the normative base approved by the Ministry of Power Engineering and Fuel Industry of Ukraine have been revealed. Influence of the operation of the power units of thermal power plants in Ukraine in the maneuver mode on the reliability and accident rate of power equipment has been analyzed and the accident rate indicators and the specific indicators of equipment reliability have been calculated. It has been established that according to the current state of the equipment the operation in the maneuver mode is undesirable and requires the development of a special normative base because it causes a considerable wear of key assets. A number of emergency stops and emergency repair hours for the thermal power plants of the ²ENERGO² Thermal Power Plant is indicative of an increased accident rate during the operation period of 2012 to 2015. Proceeding from the character of an increased number of emergency stops and emergency repair hours for thermal power plants we can make a conclusion that these indicators will considerably increase in 2016, if operated in the maneuver mode of daily start-stop.
Посилання
Levin, M. M., Babichev L. A. and Gulia O. M. (2013), ²Tehnicheskoe pereosnashhenie ugol'nyh jenergoblokov 150–300 MVt[Technical re-equipment of coal-fired power units of 150-300 MW]², Energetika ta elektrifіkacіja[Energyandelectrification],no.3,pp. 60–75, ISSN 0424-9879.
(2005), ND MPE Ukrayiny`. Kontrol` metalu i prodovzhennya terminu ekspluataciyi osnovny`x elementiv kotliv, turbinitruboprovodiv teplovy`x elektrostancij. – Ty`pova instrukciya. SOU–N MPE 40.17.401:2004 [RDofMFEU.Metalinspectionandextending operating life of main components of boilers, turbines and pipelines ofthermalpowerplants:SOU-NMPE40.17.401:2004], GRIFRE, Ministry of fuel and energy of Ukraine, Kiev, Ukraine.
Berliand, V. I. and Plotkin, E. R. (1992), ²Obobshhenie rezul'tatov iisledovanija ciklicheskoj prochnosti parovyhturbinmoshhnost'ju 160, 200 i 300 MVt pri peremennyh rezhimah [Generalized results of research of cyclicstrengthofsteamturbineswitha capacity of 160, 200 and 300 MW at different operating conditions]², Teplojenergetika[Thermalenergy],no.6, pp. 23–29.
Liubimov, A. A., Troickiy, A. I. and Hladshtein, V. I. (2013), ²Analiz sostojanija metalla parovyh turbin pofaktorambezopasnosti i nadezhnosti [Analysis of the state of the metal steam turbine safety and reliabilityfactors]²,Teplojenergetika[Thermal energy], no. 1, pp. 33–38, ISSN 0040-3636.
Berliand, V. I., Trukhniy, A. D., Skladchikov, V. P. [et al.] (1987), ²Ciklicheskaja prochnost' korpusa CVD prirazlichnyhsposobah nochnogo rezervirovanija blokov s turbinami K‑210-130-3 LMZ [Cyclic strength of HPC casingatvariouswaysofnightreserving of blocks with turbines K-210-130-3 LMZ]², Teplojenergetika [Thermal energy], no. 8,pp.26–31.
(2003), Rozraxunok pokazny`kiv nadijnosti dlya elektrostancij, teplovy`x merezh ta energokompanij. – Metody`ka.GND34.09.453-2003 [IRD. Calculation of reliability for power plants, heat and energy networks. – Methodology.IRD34.09.453-2003], GIFRE, Kyiv, Ukraine.
Prokopenko, A. G., Pavliv, Yu. V., Chetishko, I. N. [et al.] (1971), ²Issledovanie nadezhnosti i jekonomichnosti rabotyblokov200 MVt v rezhime minimal'nyh nagruzok [Research of reliability and efficiency of the 200 MWblocksofminimumloadconditions]²,Teplojenergetika [Thermal energy], no. 6, pp. 6–9.
Kobzarenko, L. N., Madojan, A. A., Arakelian, E. K. (1978), ²Optimizacija rezhimov ostanova jenergoblokov 200 MVtprivyvodah v rezerv na period provalov grafika nagruzki [Optimization of shutdown modes of 200MWpowerunitswiththeconclusions of the reserve for the period of the load curve dips]², Teplojenergetika [Thermalenergy],no. 3 pp. 9–12.
